Öhlins Front Forks for Motocross Bikes Recalled by Öhlins USA Due to Crash Hazard (Recall Alert)
CPSC Recall Notice
Source: U.S. Consumer Product Safety Commission (CPSC) — official agency notice for recall CPSC-6438.
This recall involves Öhlins RXF 48 mm front bike forks for motocross bikes. The fork legs are yellow with a large white "Ö" and a small "TTX" on the front. The fork legs measure about 37 inches long. The following product and batch numbers are included in this recall and stamped on the silver-colored front fork bottom piece. Product Number Batch Number FGKT 1586 309632 FGHO 1596 309640 FGKT 1596 309628 FGKT 1596 138461
Corrective Action (per CPSC)
Source: U.S. Consumer Product Safety Commission (CPSC) — official agency notice for recall CPSC-6438.
Consumers should stop using motocross bikes with these front forks immediately and contact Öhlins for free replacement and installation of a new cartridge kit in the fork.
✅ What you should do
- Stop using the product if you own it.
- Check the model number, lot code, or sell-by date against the recall notice above.
- Contact Off-road Bike Stores Nationwide From November 2014 Through May 2015 For About $3,500. or the retailer where you bought it for a refund, replacement, or repair.
- For the most current official instructions, visit the CPSC recall page.
- If you've been hurt by this product, report the incident to CPSC.
Consumer Contact (per CPSC)
Source: U.S. Consumer Product Safety Commission (CPSC) — official agency notice for recall CPSC-6438.
Öhlins USA at (800) 336-9029 from 9 a.m. to 5 p.m. ET Monday through Friday or online at www.ohlinsusa.com and click on Important Safety Recall for more information.
About the U.S. Consumer Product Safety Commission
The CPSC protects consumers from injuries and deaths from thousands of types of consumer products — toys, furniture, electronics, appliances, and more.
Visit CPSC.gov →📣 Report an unsafe product to the CPSC
If you own this product and experienced a defect, near-miss, or injury, file a report with the CPSC. Consumer reports are the primary signal the agency uses to identify defect patterns and trigger future recalls. Your report is free, takes about 10 minutes, and can stay anonymous to the manufacturer.
Off-road Bike Stores Nationwide From November 2014 Through May 2015 For About $3,500. Recall FAQ
Off-road Bike Stores Nationwide From November 2014 Through May 2015 For About $3,500. is the subject of a bicycles & wheeled sports recall: Öhlins Front Forks for Motocross Bikes Recalled by Öhlins USA Due to Crash Hazard (Recall Alert). The notice was published on July 9, 2015 by the U.S. Consumer Product Safety Commission (CPSC). Approximately 50 units are potentially affected.